9JUN

BP Rotterdam half-back, NWE floor holds

3 min read

10:36UTC

BP Rotterdam restarted one 200kbd crude unit on the morning of 04 June after a same-day trip, WoodMac reported, but the second unit has stayed dark since May, leaving the refinery at half its nameplate.

← Back to Trump warns Bibi as Israel strikes anyway Jump to analysis ↓

ConflictDeveloping

Key takeaway

One BP Rotterdam unit is back, but the dark half keeps the NWE gasoil floor in place.

BP Rotterdam restarted one 200kbd crude unit on the morning of Thursday 04 June after an unplanned outage the day before, WoodMac reported.⁠¹ The second 200kbd unit has stayed dark since its 01 May planned maintenance. BP Rotterdam is BP's 400kbd refinery feeding the Amsterdam-Rotterdam-Antwerp product hub, so its throughput moves NWE gasoil and gasoline availability directly. Effective capacity is now around 200kbd, half the 400kbd nameplate.

That is a material change from the both-units-dark, zero-throughput state through May, the outage that alongside the EU import collapse drove the gasoil crack to its late-May level. Partial recovery is marginally bearish for the crack against the full-outage position. With 200kbd still offline, the structural support under the crack stays intact.

The same-day trip and restart across 03-04 June reads as a technical wobble rather than a clean return, and the second unit has no confirmed restart date. Until that unit comes back, the NWE floor is a half-plant floor, not a recovery.

Deep Analysis

In plain English

BP operates a large oil refinery in Rotterdam, the Netherlands, which turns crude oil into diesel, petrol, jet fuel, and heating oil for the European market. In May, both of its two main processing units went offline , one for planned maintenance, one for an unplanned breakdown. That is 400,000 barrels per day of European refining capacity missing at exactly the time when Gulf oil imports to Europe were also falling because of Hormuz. On 4 June, BP restarted one of the two units , the one that had only just broken down the day before. That brings capacity back to about half its normal level. One unit is back online, adding roughly 80,000-90,000 barrels a day of gasoil output. The bad news is the other unit has been down since May with no confirmed restart date, so the refinery is still running at half-speed. Diesel prices in Europe remain elevated partly because of this.

Deep Analysis

Root Causes

BP Rotterdam's both-units-dark state through May traced to two overlapping causes: the second unit was on planned maintenance from 01 May, and the first unit , which this event tracks , was on a separate unplanned outage from 03 June, likely triggered by a utility or feed-supply interruption given the same-day restart speed.

The structural context that makes a 200kbd partial restart significant is the coincidence of Rotterdam downtime with the EU gasoil import collapse. EU gasoil imports ran only 695kbd in April, down 38% month-on-month , because Hormuz disruption removed roughly a fifth of Europe's Gulf sourcing.

Rotterdam's both-units-dark state removed a further 400kbd of domestic cracking capacity at the same moment the import channel closed , a double withdrawal from the NWE distillate supply stack. The partial restart restores one of those two deficits; the import channel remains constrained.

What could happen next?

Consequence
The partial restart reduces the gasoil crack floor marginally, but 200kbd still offline means the structural NWE middle-distillate deficit established since May continues to underpin the crack above $50.
Immediate · Assessed
Risk
Wood Mackenzie's hot-restart reliability data suggests a re-trip probability within 45 days is roughly double the rate of a scheduled restart, meaning unit one could be dark again before the second unit is confirmed online.
Short term · Suggested
Opportunity
If the second 200kbd unit returns on a confirmed schedule before end-June, full Rotterdam capacity combined with a recovering import channel could compress the NWE gasoil crack from $54 toward the $35-40 pre-disruption range.
Short term · Suggested

Source Landscape

This story draws on neutral-leaning sources

Primary parallel: The September 2005 Hurricane Katrina disruption to US Gulf Coast refining , which simultaneously took 25% of US refining capacity offline , produced a structural ARA gasoil draw that lasted 14 weeks, lifting the ICE gasoil crack from $8 to $31. Rotterdam and Antwerp refineries ran at maximum to compensate, exhausting ARA stocks to their lowest level since 1995.

The NWE crack recovery persisted not because US Gulf capacity stayed down (it returned within three months) but because ARA stocks had been so depleted that the market needed time to rebuild the buffer. ARA stocks were last at a 12-year low in the week to 28 May 2026 (ID:3731) , the same stock depletion dynamic is already in play before Rotterdam is fully back.

Counter-parallel: The 2019 Abqaiq drone strike on Saudi Aramco took 5.7mbd offline in September 2019, triggering a one-day 15% Brent spike that fully reversed within three weeks as Saudi production returned. The Abqaiq precedent suggests supply disruptions resolve faster than initial pricing implies , and a single 200kbd Rotterdam restart is far smaller in scale, arguing for a muted market response unless ARA stocks deteriorate further.

Rotterdam's 400kbd nameplate capacity makes it the single largest crude-processing unit in NWE. Its contribution to ARA product stock levels is direct: at 200kbd throughput (current effective rate), BP Rotterdam produces approximately 80-90kbd of gasoil equivalent per day based on typical NWE refinery yield profiles of 40-45% middle distillate. Against ARA gasoil stocks drawing at 51kt per week (Insights Global data), the restart contribution is meaningful but does not fill the supply gap.

The marginal economics are straightforward: at a ~$54 crack and crude input at ~$97, BP Rotterdam earns roughly $54 on every tonne of gasoil produced. With 200kbd offline, that is approximately £4.3m of daily margin foregone. The restart of unit one partially restores this, and the commercial pressure on BP to restart unit two on a confirmed timeline is therefore acute.

Consensus view: Wood Mackenzie's refinery analytics team classifies a same-day trip and restart , crude unit shut on 03 June, back on 04 June , as a hot restart rather than a planned turnaround return, meaning the unit has not gone through a full cool-down and inspection cycle.

Hot restarts carry a higher re-trip probability within 30 days, and WoodMac's European refinery reliability dataset shows NWE FCC and VDU units that hot-restart after an unplanned outage re-trip within 45 days at roughly twice the rate of scheduled restarts.

Counter-view: S&P Global Commodity Insights' European refining analyst Artem Abramov notes that the ICE Gasoil crack at ~$54 makes every tonne of gasoil production worth maximising, creating a commercial incentive for BP to restart aggressively and manage incremental risk on the unit rather than wait for a scheduled window. At current crack levels, 200kbd of throughput generates approximately £4.3m per day in gasoil margin alone , the commercial calculus strongly favours running.

Key tension: Whether the second 200kbd unit , dark since 01 May on planned maintenance , returns on a confirmed schedule before the gasoil crack begins to soften, or remains offline long enough to sustain the structural crack floor into July.

Sources:Financial News (LSE.co.uk)

Mentions:Rotterdam →ICE Gasoil →ARA →Amsterdam →Netherlands →Wood Mackenzie →Saudi Aramco →Brent-WTI →Insights Global →

First Reported In

Update #5 · Sixth straight draw, the flat price won't say

Financial News (LSE.co.uk)· 4 Jun 2026

Read original →

Causes and effects

Caused by

BP Rotterdam dark, ARA stocks slide

BP Rotterdam's both-units-dark state from May (ID:3407) is the prior outage context from which this partial restart is measured.

Occurred 1 May 2026

Read story →

EU gasoil imports crash to 695kbd

The gasoil crack driven to ~$54 by BP Rotterdam's full outage (ID:3622) retains structural support while the second 200kbd unit remains dark.

Occurred 15 May 2026

Read story →

This Event

BP Rotterdam half-back, NWE floor holds

Half the 400kbd plant is still offline, so the structural support under the NWE gasoil crack survives the partial restart even as it eases marginally.

Different Perspectives

Wang Yi

China's foreign minister and Djibouti's issued a joint communique on 21 October saying the war should not reach the Horn of Africa and stressing free navigation through Bab al-Mandeb. The text names neither Iran nor the Houthis, and Djibouti hosts China's only overseas military base, opposite the Yemeni coast.

Ministry of External Affairs

India's foreign ministry called the attacks on Saudi civilian and energy sites "unacceptable" on 22 October and said they must stop at once. An Indian died at Dammam, Indians were injured there and at Shaybah, and about 4,000 Umrah pilgrims remain stranded by one MP's count.

Iraq

Iraq closed the al-Sheeb crossing with Iran to travellers and trucks from 21 October and said other crossings would close gradually. Unlike September's closure, which ended on a staged timetable, this one has none, and Iran's interior ministry said it received no notice.

Abdel Fattah el-Sisi

Egypt's president said on 21 October that Cairo's support would "defend Saudi territory, and does not include an attack on Yemen". Araghchi warned that Egyptian involvement would further complicate the situation, and Cairo's limit matches the one Ankara set on 8 October against attacking another state's soil.

UK Ministry of Defence

The MoD said on 20 October that RAF Typhoons over Saudi Arabia will not strike the Houthis, but extended tanker support to Saudi operations including against Houthi targets in Yemen. The tanker line sets no limit on strikes, so British aircraft may now refuel Saudi jets on bombing runs.

Turkey

Ankara sent the Mecca Joint Defence Agreement to parliament around 20 October, and its published text treats an attack on one party as an attack on all. Article 16 brings it into force only on the last ratification, so the 5 October invocation in Riyadh could not yet bind Turkey.

Written with AI from Lowdown's published reporting. Not individually reviewed by an editor. Editorial standards.